คิดถึงทุกลมหายใจ

Soil-cement

What is Soil-Cement

Soil-cement is a highly compacted mixture of soil/aggregate, portland cement, and water. Soil-cement differs from portland cement concrete pavements in several respects. One significant difference is the manner in which the aggregates or soil particles are held together. A portland cement concrete pavements mix contains sufficient paste (cement and water mixture) to coat the surface area of all aggregates and fill the void between aggregates. In soil-cement mixtures, the paste is insufficient to fill the aggregate voids and coat all particles, resulting in a cement matrix that binds nodules of uncemented material



The soil material in soil-cement can be almost any combination of sand, silt, clay, gravel, or crushed stone. Local granular materials, such as slag, caliche, limerock, and scoria, plus a wide variety of waste materials including cinders, fly ash, foundry sands, and screenings from quarries and gravel pits, can all be utilized as soil material. Old granular-base roads, with or without bituminous surfaces, can also be reclaimed to make great soil-cement.



Soil-cement is sometimes called cement-stabilized base, or cement-treated aggregate base. Regardless of the name, the principles governing its composition and construction are the same.


copy from //www.cement.org

//www.cement.org/pavements/pv_sc_scb.asp











 

Create Date : 03 ตุลาคม 2549
8 comments
Last Update : 3 ตุลาคม 2549 13:59:55 น.
Counter : 806 Pageviews.

 

อะไรคือ soil cement

ดินลูกรัง ที่บดละเอียด และนำมา ผสมกับ ปูนซีเมนต์ และน้ำสะอาด ในอัตราส่วนที่เหมาะสม

เมื่ได้สัดส่วนที่ลงตัว สามารถ นำมาทพเป็น ถนนอินซีเมนต์ ด้วยการ บดอัดแน่น ในปริมาณ แรงอัดที่ได้ทดสอบมาแล้ว

จะเห็นได้จาก ถนนตามชนบท

จากทฤษฎีดังกล่าว จึงทำให้เกิตเครื่องอัดดิน ขึ้นรูปเป็น บล็อกสี่เหลี่ยม เพื่อนำมาก่อสร้างบ้านเรือนต่างๆ
ด้วยการใช้วัตถุดิบเช่นเดียวการทำถนน

 

โดย: ป๋าวี (ป๋าวี ) 3 ตุลาคม 2549 14:10:10 น.  

 

Compared to regular Concrete....
Soil Cement can be very similar to the concrete delivered by the redi-mix trucks at rather high prices, which prices increase if the load is small or if it takes you too long to pour it. But the materials?.... Redi-mix concrete use sand and gravel - the same stuff you may find on your building site. It is washed and screened for size, then combined with concrete and water in ratios appropriate for the project. You'll have problems if it contains too much clay, and certainly you don't need leaves, roots, grass, or other debris - just dig down and get the good stuff.

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:15:53 น.  

 

Engineering:
The chief variable in any soil-cement mix is in the native materials available. Sand and rock is good; clays give shrinkage problems & increase the percentage of portland cement - plant roots and humus are bad for strength and a problem when finishing. Every case has its own unique characteristics.
When one is pouring thick walls of soil cement, the strength of the mix is critical. Concrete is tremendously heavy stuff - it weighs 144 pounds per cubic foot, which ironically works out to 1 psi (pounds per square inch) per vertical foot of wall load imposed. But, considering that the concrete we normally use in footings is 2,500 psi, there's a lot of latitude! One may wish to consult an engineer about such things

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:16:54 น.  

 

The loads imposed by walls typically 9 or more feet tall must be considered, both in the design of footings and in the mix for the walls. For cost-saving, the ratio of portland cement in the mix may be reduced as the wall height increases and the imposed loads are smaller.

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:17:41 น.  

 

Footings: This house will be HEAVY - you'll need decent bearing - solid ground or rock. A conservative rule of thumb is that undisturbed soil below frost-line should bear 1000 # / SqFt. The minimum horizontal rebar would be 2 #4 (1/2") running horizontally; you may need more.

Of course the advantage of all this weight is in its utilization as thermal mass, the essential element in any passive solar home.

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:18:50 น.  

 

Testing: Where there are concerns about the strength of the mix, pouring test cylinders is simple and inexpensive; testing companies can be found almost everywhere

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:19:53 น.  

 

Reinforcing with re-bar and/or wire mesh would be required by building codes for most soil-cement wall construction. It's not especially expensive, and as it greatly enhances the strength and stability of the footings and walls, one would be foolish to ignore it! Again, consulting an engineer is prudent, and may well save money by avoiding over-reinforcement just to cover our own ignorance

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:20:46 น.  

 

//zelltree.com/solarsense/SoilCement.htm

 

โดย: ป๋าวี 3 ตุลาคม 2549 14:26:38 น.  

ชื่อ :
Comment :
  *ใช้ code html ตกแต่งข้อความได้เฉพาะสมาชิก
 


ป๋าวี
Location :


[ดู Profile ทั้งหมด]

ฝากข้อความหลังไมค์
Rss Feed

ผู้ติดตามบล็อก : 1 คน [?]




Group Blog
 
<<
ตุลาคม 2549
1234567
891011121314
15161718192021
22232425262728
293031 
 
3 ตุลาคม 2549
 
All Blogs
 
Friends' blogs
[Add ป๋าวี's blog to your web]
Links
 

 Pantip.com | PantipMarket.com | Pantown.com | © 2004 BlogGang.com allrights reserved.